Design and Performance Evaluation of A Portable Low-Head Pico-Hydro System using A Rewound Axial Generator for Rural Energy
DOI:
https://doi.org/10.31961/eltikom.v9i1.1489Keywords:
generator, pico-hydro, performance, transformer, voltageAbstract
This study evaluates the performance of a pico-hydro system installed on a river with low head and discharge. The system was assessed under no-load and varying load conditions (25–100%). The results indicate that the generator performs according to the initial design, despite some fluctuations in output parameters. Under no-load conditions, the generator maintains a stable output voltage between 12–14 VAC, with a rotational speed of 590–600 RPM, a system frequency of 59–60 Hz, and zero current. The step-up transformer successfully raises the voltage to 220–222 V with high stability, although minor ripple is observed in the output signal. Under load, the generator voltage slightly decreases to 12–14 V as the load increases. The rotational speed also declines (560–590 RPM), affecting frequency stability, which drops from 59 Hz at 25% load to 56 Hz at full load. The current rises proportionally with the load, from 0.10 A at 25% to 0.45 A at 100%. The observed performance drop under load highlights the effect of load on generator speed and overall system output. The primary impacts of the 25–100% load range are evident in generator speed, frequency stability, and waveform quality. Overall, the system performs satisfactorily for low-head pico-hydro applications with a power capacity of up to 100 Watts, suitable for rural street lighting.
Downloads
References
P. Gabrielli et al., “Net-zero emissions chemical industry in a world of limited resources,” Jun. 16, 2023, Cell Press. doi: 10.1016/j.oneear.2023.05.006.
R. S. Haszeldine, S. Flude, G. Johnson, and V. Scott, “Negative emissions technologies and carbon capture and storage to achieve the Paris Agreement commitments,” May 13, 2018, Royal Society Publishing. doi: 10.1098/rsta.2016.0447.
J. Rogelj, “Net zero targets in science and policy,” Environmental Research Letters, vol. 18, no. 2, Feb. 2023, doi: 10.1088/1748-9326/acb4ae.
Y. Kaya, M. Yamaguchi, and O. Geden, “Towards net zero CO2 emissions without relying on massive carbon dioxide removal,” Nov. 01, 2019, Springer Tokyo. doi: 10.1007/s11625-019-00680-1.
Y. Jiang et al., “Multi–Disciplinary Optimizations of Small-Scale Gravitational Vortex Hydropower (SGVHP) System through Compu-tational Hydrodynamic and Hydro–Structural Analyses,” Sustainability (Switzerland), vol. 14, no. 2, Jan. 2022, doi: 10.3390/su14020727.
M. M. Rahman, J. H. Tan, M. T. Fadzlita, and A. R. Wan Khairul Muzammil, “A Review on the Development of Gravitational Water Vortex Power Plant as Alternative Renewable Energy Resources,” in IOP Conference Series: Materials Science and Engineering, Insti-tute of Physics Publishing, Jul. 2017. doi: 10.1088/1757-899X/217/1/012007.
D. Vasile Banyai, I. Radu Pop, D. Opruta, And L. Ioan Vaida, “Acta Technica Napocensis Series: Applied Mathematics Optimal Flow Control For Increased Electricity Production In Small Hydropower Plants,” 2018.
I. Torrefranca, R. E. Otadoy, and A. Tongco, “Incorporating Landscape Dynamics in Small-Scale Hydropower Site Location Using a GIS and Spatial Analysis Tool: The Case of Bohol, Central Philippines,” Energies (Basel), vol. 15, no. 3, p. 1130, Feb. 2022, doi: 10.3390/en15031130.
F. Paundra and A. Nurdin, “Study Of The Potential And Development Of Renewable Energy Power In Indonesia : A Review,” Steam Engineering, vol. 3, no. 2, pp. 62–72, Mar. 2022, doi: 10.37304/jptm.v3i2.4024.
Aripriharta, D. A. Putri, A. P. Wibawa, Sujito, M. C. Bagaskoro, and S. Omar, “Techno economic analysis of PV pumping system for rural village in East Java,” e-Prime - Advances in Electrical Engineering, Electronics and Energy, vol. 10, p. 100779, Dec. 2024, doi: 10.1016/j.prime.2024.100779.
R. Irwansyah, Warjito, Budiarso, C. Clement Rusli, and S. B. Nasution, “Analysing Hydraulic Efficiency of Water Vortex Pico-Hydro Turbine using Numerical Method,” Journal of Advanced Research in Fluid Mechanics and Thermal Sciences, vol. 77, no. 2, pp. 91–101, Nov. 2020, doi: 10.37934/arfmts.77.2.91101.
I. Samora, V. Hasmatuchi, C. Münch-Alligné, M. J. Franca, A. J. Schleiss, and H. M. Ramos, “Energy production with a tubular propel-ler turbine,” IOP Conference Series Earth and Environmental Science, vol. 49, p. 102001, Nov. 2016, doi: 10.1088/1755-1315/49/10/102001.
M. Kiraga, “Hydroelectric Power Plants and River Morphodynamic Processes,” Journal of Ecological Engineering, vol. 22, no. 7, pp. 163–178, 2021, doi: 10.12911/22998993/139068.
G. J. Jong, Aripriharta, Hendrick, and G. J. Horng, “A Novel Queen Honey Bee Migration (QHBM) Algorithm for Sink Repositioning in Wireless Sensor Network,” Wirel Pers Commun, vol. 95, no. 3, pp. 3209–3232, Aug. 2017, doi: 10.1007/s11277-017-3991-z.
L. C. Alvear Pérez, M. J. Anaya Acosta, and C. A. Pedraza Yepes, “CFD simulation data of a pico-hydro turbine,” Data Brief, vol. 33, Dec. 2020, doi: 10.1016/j.dib.2020.106596.
A. Aripriharta, E. Asnarindra, A. D. Nibrosoma, L. Gumilar, and M. A. Habibi, “Pelacakan Daya Maksimum Photovoltaic Dalam Keadaan Transisi Berbayang Menggunakan Algoritma Mppt Queen Honey Bee Migration (QHBM),” Transmisi: Jurnal Ilmiah Teknik Elektro, vol. 25, no. 3, pp. 85–94, Jul. 2023, doi: 10.14710/transmisi.25.3.85-94.
E. Gallego, A. Rubio-Clemente, J. Pineda, L. Velásquez, and E. Chica, “Experimental analysis on the performance of a pico-hydro Turgo turbine,” Journal of King Saud University - Engineering Sciences, vol. 33, no. 4, pp. 266–275, May 2021, doi: 10.1016/j.jksues.2020.04.011.
A. Židonis, D. S. Benzon, and G. A. Aggidis, “Development of hydro impulse turbines and new opportunities,” Aug. 07, 2015, Elsevier Ltd. doi: 10.1016/j.rser.2015.07.007.
K. Shimokawa, A. Furukawa, K. Okuma, D. Matsushita, and S. Watanabe, “Experimental study on simplification of Darrieus-type hydro turbine with inlet nozzle for extra-low head hydropower utilization,” Renew Energy, vol. 41, pp. 376–382, May 2012, doi: 10.1016/j.renene.2011.09.017.
A. Date, A. Date, and A. Akbarzadeh, “Investigating the potential for using a simple water reaction turbine for power production from low head hydro resources,” Energy Convers Manag, vol. 66, pp. 257–270, 2013, doi: 10.1016/j.enconman.2012.09.032.
I. Torrefranca, R. E. Otadoy, and A. Tongco, “Incorporating Landscape Dynamics in Small-Scale Hydropower Site Location Using a GIS and Spatial Analysis Tool: The Case of Bohol, Central Philippines,” Energies (Basel), vol. 15, no. 3, p. 1130, Feb. 2022, doi: 10.3390/en15031130.
K. Gaiser, P. Erickson, P. Stroeve, and J.-P. Delplanque, “An experimental investigation of design parameters for pico-hydro Turgo turbines using a response surface methodology,” Renew Energy, vol. 85, pp. 406–418, Jan. 2016, doi: 10.1016/j.renene.2015.06.049.
S. R. Sheikh et al., “A Low-Cost Sustainable Energy Solution for Pristine Mountain Areas of Developing Countries,” Energies (Basel), vol. 14, no. 11, p. 3160, May 2021, doi: 10.3390/en14113160.
E. Akbari and M. S. Shadlu, “A Novel Modified Fuzzy-Predictive Control of Permanent Magnet Synchronous Generator Based Wind Energy Conversion System,” Chinese Journal of Electrical Engineering, vol. 9, no. 4, pp. 107–121, Dec. 2023, doi: 10.23919/CJEE.2023.000042.
S. J. Williamson, A. Griffo, Stark. B.H, and Booker. J.D, Control of Parallel Single-Phase Inverters in a Low-Head Pico-Hydro Off-Grid Network. 2013.
D. Mitrovic et al., “Multi-Country Scale Assessment of Available Energy Recovery Potential Using Micro-Hydropower in Drinking, Pressurised Irrigation and Wastewater Networks, Covering Part of the EU,” Water (Basel), vol. 13, no. 7, p. 899, Mar. 2021, doi: 10.3390/w13070899.
L. Chang and W. Wei, “Numerical study on the effect of tangential intake on vortex dropshaft assessment using pressure distribu-tions,” Engineering Applications of Computational Fluid Mechanics, vol. 16, no. 1, pp. 1100–1110, Dec. 2022, doi: 10.1080/19942060.2022.2072954.
W. Cao, “Comparison of IEEE 112 and new IEC standard 60034-2-1,” IEEE Transactions on Energy Conversion, vol. 24, no. 3, pp. 802–808, 2009, doi: 10.1109/TEC.2009.2025321.
A. E. Putra, “Perancangan Dan Pembuatan Generator Fluks Radial Satu Fasa Menggunakan Lilitan Kawat Sepeda Motor Dengan Variasi Diameter Kawat,” 2014.
C.-S. Yi, K.-H. Kim, J.-H. Lee, and M.-P. Shim, “Location Analysis for Developing Small Hydropower Using Geo-Spatial Information System,” Journal of Korea Water Resources Association, vol. 40, no. 12, pp. 985–994, Dec. 2007, doi: 10.3741/jkwra.2007.40.12.985.
E. Gómez-Llanos, P. Durán-Barroso, J. Arias-Trujillo, J. M. Ceballos-Martínez, J. A. Torrecilla-Pinero, and M. Candel-Pérez, “Small and Micro-Hydropower Plants Location by Using Geographic Information System,” MDPI AG, Oct. 2018, p. 1300. doi: 10.3390/proceedings2201300.
R. Ayu Mustikasari and T. Hardianto, “Analisis Generator Sinkron Permanen Magnet (PMSG) Tipe Radial 3 Fasa dengan Hubungan Kumparan Delta.”
E. Buchicchio, A. De Angelis, F. Santoni, P. Carbone, F. Bianconi, and F. Smeraldi, “Battery SOC estimation from EIS data based on machine learning and equivalent circuit model,” Energy, vol. 283, Nov. 2023, doi: 10.1016/j.energy.2023.128461.
Y. Zhu, Y. Xiong, J. Xiao, T. Yi, C. Li, and Y. Sun, “An improved coulomb counting method based on non-destructive charge and discharge differentiation for the SOC estimation of NCM lithium-ion battery,” J Energy Storage, vol. 73, Dec. 2023, doi: 10.1016/j.est.2023.108917.
S. Amini, S. Bahramara, H. Golpîra, B. Francois, and J. Soares, “Techno-Economic Analysis of Renewable-Energy-Based Micro-Grids Considering Incentive Policies,” Energies (Basel), vol. 15, no. 21, Nov. 2022, doi: 10.3390/en15218285.
İ. Çetinbaş, B. Tamyürek, and M. Demirtaş, “Design, analysis and optimization of a hybrid microgrid system using HOMER software: Eskişehir osmangazi university example,” International Journal of Renewable Energy Development, vol. 8, no. 1, pp. 65–79, Feb. 2019, doi: 10.14710/ijred.8.1.65-79.
A. Günther, J. Gütschow, and M. L. Jeffery, “NDCmitiQ v1.0.0: a tool to quantify and analyse greenhouse gas mitigation targets,” Geosci Model Dev, vol. 14, no. 9, pp. 5695–5730, Sep. 2021, doi: 10.5194/gmd-14-5695-2021.
X. Li, Y. Li, H. Zhou, Z. Fu, X. Cheng, and W. Zhang, “Research on the Carbon Emission Baselines for Different Types of Public Build-ings in a Northern Cold Areas City of China,” Buildings, vol. 13, no. 5, p. 1108, Apr. 2023, doi: 10.3390/buildings13051108.
Ł. Skowron et al., “Interconnection between the Dynamic of Growing Renewable Energy Production and the Level of CO2 Emissions: A Multistage Approach for Modeling,” Sustainability, vol. 15, no. 12, p. 9473, Jun. 2023, doi: 10.3390/su15129473.
A. Günther, J. Gütschow, and M. L. Jeffery, “NDCmitiQ v1.0.0: a tool to quantify and analyse greenhouse gas mitigation targets,” Geosci Model Dev, vol. 14, no. 9, pp. 5695–5730, Sep. 2021, doi: 10.5194/gmd-14-5695-2021.
E. Gallego, A. Rubio-Clemente, J. Pineda, L. Velásquez, and E. Chica, “Experimental analysis on the performance of a pico-hydro Turgo turbine,” Journal of King Saud University - Engineering Sciences, vol. 33, no. 4, pp. 266–275, May 2021, doi: 10.1016/j.jksues.2020.04.011.
[2] A. Židonis, D. S. Benzon, and G. A. Aggidis, “Development of Hydro Impulse Turbines and New Opportunities.”
[3] I. Torrefranca, R. E. Otadoy, and A. Tongco, “Incorporating Landscape Dynamics in Small-Scale Hydropower Site Location Using a GIS and Spatial Analysis Tool: The Case of Bohol, Central Philippines,” Energies (Basel), vol. 15, no. 3, Feb. 2022, doi: 10.3390/en15031130.
S. J. Williamson, A. Griffo, B. H. Stark, and J. D. Booker, “Control of parallel single-phase inverters in a low-head pico-hydro off-grid network,” in IECON 2013 - 39th Annual Conference of the IEEE Industrial Electronics Society, 2013, pp. 1571–1576. doi: 10.1109/IECON.2013.6699367.
S. R. Sheikh et al., “A low-cost sustainable energy solution for pristine mountain areas of developing countries,” Energies (Basel), vol. 14, no. 11, Jun. 2021, doi: 10.3390/en14113160.
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2025 Aripriharta Aripriharta, Ahmad Dhaffa Nibrosoma, Arif Nur Afandi, Mohamad Rodhi Faiz, Nur Aini Syafrina Rahmadhani, Muhammad Cahyo Bagaskoro, Norzanah Rosmin
This work is licensed under a Creative Commons Attribution 4.0 International License.
All accepted papers will be published under a Creative Commons Attribution 4.0 International (CC BY 4.0) License. Authors retain copyright and grant the journal right of first publication. CC-BY Licenced means lets others to Share (copy and redistribute the material in any medium or format) and Adapt (remix, transform, and build upon the material for any purpose, even commercially).
